logo

Sanitization Tunnel


Personnel Decontamination/Sanitization for Safety against a wide range of microorganisms including bacteria, yeasts, fungi, viruses including Coronavirus, and spores.

PUF Insulated Walkable Tunnel in the sizes of 4X8X4 Feet, 4X4X8 Feet & 12X4X8 Feet with Mist Nozzels, Automatic Mist Pump and Step in Sensor & Timer

LED Light

Memory Foam on Floor for Shoe Sanitization

Optional Air Curtain for Shake off excess Mist

Over View

This walk through enclosure is designed for personnel decontamination, one person at a time.

A Person is passed through mist of Sanitization liquid.

A Sanitization Solution is Sprayed in the form of mist for 5 seconds on the person walking through slowly with raised hand.

The Solution consists of Mild Hydrogen Peroxide, Super Distilled Water and Iso Propyl Alcohol (IPA) –Third Party Lab Tested

In the system there are total 10-12 misting nozzles which are installed on both sides of the chamber in two columns; four nozzles each on both side of the chamber which operates automatically by a Sensor & timer circuit.

When a person comes in front of theTunnel, the pump operates automatically and in turn misting starts from all the 10-12 nozzles

The nozzles are operative for 5 seconds which is required for proper sanitisation. After which the pump stops automatically

Misting Solution is efficient enough to kill the virus on body/ clothes

Utilization

Malls, Large Departmental Sores, Whole sale Mandies, Offices and Complexes, Industries, Airports, Educational Institutes, Cinema Halls, Hospitals.

Sanitisation Solution

We Use Solution Containing small percentage of Hydrogen peroxide, Super Distilled Water and Iso Propyl Alcohol (IPA)

The most commonly used chemical for Sanitizing/ fogging is Hydrogen Peroxide. Hydrogen Peroxide is the safest chemical to use for Sanitizing/fogging. Unlike bleach, which would create a possibly harmful vapor, Hydrogen Peroxide vapor is relatively safe.

Hydrogen Peroxide are also included on the Center for Biocide Chemistries list of agents that are effective against the COVID-19 Coronavirus and approved by CDC

  • Hydrogen Peroxide is active against a wide range of microorganisms, including bacteria, yeasts, fungi, viruses, and spores.
  • Hydrogen peroxide is considered an environmentally safe alternative to chlorine-based bleaches as it breaks down into water and oxygen
  • Hydrogen peroxide (H2O2) is water with an extra o x y g e n m o l e c u l e . U n l i k e chlorine bleach, it breaks down into oxygen and water and is kind to the environment.
  • Hydrogen peroxide reacts very fast. It will than disintegrate into hydrogen and water, without the formation of byproducts. This increases the amount of oxygen in water and it is Safe

Full Body Sanitization Tunnel Specification

  • Size: 8X4X8 Feet, 4X4X8 Feet and 12X4X8 Feet configurations
  • Body/Structure: Is made of 30 mm Thick PUF Insulated Panels with Pre Coated Galvanized Skin. Having it’s own strength.
  • Environmentally safe blowing agent is used in making PUF Panels replacing harmful HCFC.
  • Floor is 50 mm Thick PUF Insulated Panels with Pre Coated Galvanized Skin. With 30 mm Memory Foam on top for Shoe Sole Sanitization
  • Hand Sanitizing Pump assembly before entering the Sanitization Chamber.
  • Sensor operated Sprayer & Mist Fogging System for the spray of disinfectant Liquid having 300 PSI Pump.
  • Power Requirement – Single Phase
  • SS/ Hard Plastic Tank for Disinfectant Solution
  • The spray of disinfectant liquid is for 5 Seconds
  • Sanitizing Capacity-10 - 11 Px per minute
  • The Disinfectant Liquid of 85 Lt is sufficient for approximately 1400 Px
  • It can work for 140 minutes uninterrupted before gap for refilling. Which should not be of more then 5 minutes
  • Disinfectant cost per person is approximately Rs 1.5

Certifications

ISO 9001-2015

u Safety from the Used Solution- NABL Approved Lab

u Approved Composition of Solution from from NABL Approved Lab